Fuses and relays Jeep Wrangler (TJ 1997-2006)

Fuse Layout Jeep Wrangler 1997-2006

Fuses and relays Jeep Wrangler (TJ 1997-2006)

Fuse Box Location

Passenger Compartment

The fuse panel is located behind the glove box.Fuses and relays Jeep Wrangler (TJ 1997-2006)

To access the fuse panel the glove box must be removed. It is removed by slipping the glove box strap off the hook and letting the door roll down off its hinges. To reinstall, position the glove box door at an 8 o’clock orientation, engage the hinge hook formations on the lower edge of the glove box door with the hinge pins on the lower edge of the instrument panel. Tilt the upper edge of the glove box door upward toward the instrument panel enough to reattach the glove box strap to the door. Rotate glove box door to closed position. Open and close to insure proper installation.

Engine Compartment

Your vehicle is equipped with an electrical power distribution center located in the engine compartment near the battery.Fuses and relays Jeep Wrangler (TJ 1997-2006)

This power center houses plug-in “Cartridge” fuses, ISO relays, and Mini (Micro) fuses. A label inside the latching cover of the center identifies each component for ease of replacement, if necessary. Cartridge and mini (micro) fuses can be obtained from your authorized dealer.

Fuse Box Diagrams

Passenger Compartment

Fuses and relays Jeep Wrangler (TJ 1997-2006)

Fuses and relays Jeep Wrangler (TJ 1997-2006)

Assignment of the interior fuses

Amp Rating Description
1 20 Headlamp Switch (Multi-Function Switch), Sentry Key Immobilizer Module
2 20 Brake Lamp Switch
3 10 / 20 1997-1998: Fog Lamp Relay №1 (20A);

1999-2002: “PRNDL” Lamp, Front Fog Lamp Switch, Radio, Rear Window Defogger Switch (Hard Top), A/C Heater Control, Rear Wiper/Washer Switch (Hard Top), Instrument Cluster, Rear Fog Lamp Switch, Headlamp Switch (10A)

2003-2006: Subwoofer, Radio Choke and Relay (20A)

4 10 Driver Door Ajar Switch, Passanger Door Ajar Switch, Fog Lamp Relay №1, Fog Lamp Relay №2, Rear Fog Lamp Relay
5 10 Airbag Control Module
6 20 Rear Wiper Motor (Hard Top), Rear Wiper/Washer Switch (Hard Top)
7 10 Park/Neutral Position (PNP) Switch (Automatic Transmission), Back-Up Lamp Switch (Manual Transmission), Controller Antilock Brake (ABS), Air Conditioner Compressor Clutch Relay, Rear Window Defogger Relay, ABS Relay
8 10 / 20 1997-1998: A/C Heater Control (20A);

1999-2006: A/C Heater Control, HVAC Unit, Blower Motor Relay, Blend Door Actuator (10A)

9 10 Airbag Control Module, Passenger Airbag On/Off Switch
10 10 Brake Shift Interlock Solenoid, Instrument Cluster, Compass/Temperature Mirror
11 10 1997-1998: Daytime Running Lamp Module, Torque Converter Clutch Solenoid, Duty Cycle EVAP/Purge Solenoid, Air Conditioner Compressor Clutch Relay, Immobilizer Module, EVAP Leak Detection Pump, Powertrain Control Mudele, Automatic Shut Down Relay, Fuel Pump Relay, Rear Window Defogger Relay;

1999-2006: Daytime Running Lamp Module, Torque Converter Clutch Solenoid, Duty Cycle EVAP/Purge Solenoid, Air Conditioner Compressor Clutch Relay

12 10 1997-1998: “PRNDL” Lamp, Front Fog Lamp Switch, Radio, Rear Window Defogger Switch (Hard Top), A/C Heater Control, Rear Wiper/Washer Switch (Hard Top), Instrument Cluster, Rear Fog Lamp Switch;

1999-2006: Sentry Key Immobilizer Module, Fuel Pump Relay, Automatic Shut Down Relay, Powertrain Control Module, Oxygen Sensor Downstream Heater Relay, Oxygen Sensor Upstream Heater Relay

13 10 Turn Signal/Hazard Switch (Multi-Function Switch), Passenger Airbag On/Off Switch (“97-“98)
14 10 / 20 / 25 1997-1999: Windshield Wiper Switch, Windshield Wiper Motor (20A);

2000-2002: Windshield Wiper Switch, Windshield Wiper Motor (25A);

2003-2006: Radio (10A)

15 10 1997-2002: Radio;

2003-2006: Rear Window Defogger Switch (Hard Top)

16 10 Headlamp Leveling Motor, Headlamp Leveling Switch, Rear Fog Lamp Relay
17 10 / 25 1997-2002: Rear Window Defogger Switch (Hard Top) (10A);

2003-2006: Windshield Wiper Motor, Windshield Wiper Switch (Multi-Function Switch) (25A)

18 15 / 20 1997-2002: Unswitched Auxiliary Power (15A);

2003-2006: Cigar Lighter/Power Outlet, Switched Auxiliary Power (20A)

19 20 1997-2002: Cigar Lighter/Power Outlet, Switched Auxiliary Power;

2003-2006: Spare

20 20 Engine Starter Motor Relay, Clutch Pedal Position Switch (Manual Transmission)

Engine Compartment

1997-1998

Fuses and relays Jeep Wrangler (TJ 1997-2006)

Assignment of the fuses in the engine compartment (1997-1998)

Amp Rating Description
2 40 Ignition Switch (Fuse (Passenger Compartment): “5”, “6”, “7”, “8”, “20”), Engine Starter Motor Relay, Clutch Pedal Position Switch (Manual Transmission)
3 30 Ignition Switch (Cigar Lighter/Accessory Relay, Fuse (Passenger Compartment): “9”, “10”, “11”, “13”, “14”, “15”)
4 40 Passenger Compartment Fuse Block: “1”, “2”, “3”
5 40 Cigar Lighter/Accessory Relay (Passenger Compartment Fuse Block: “18”, “19”)
6 30 Automatic Shut Down Relay, Powertrain Control Module
7 Not Used
8 Not Used
9 20 Turn Signal/Hazard Switch
10 30 Headlamp Switch
11 40 Blower Motor Relay
12 Not Used
13 30 ABS Relay
14 40 ABS Pump Motor Relay
15 40 Rear Window Defogger Relay
16 20 Fuel Pump Relay
17 10 Dome Lamp, Instrument Cluster, Data Link Connector, Radio, Courtesy Lamp, Underhood Lamp, Sound Bar Dome Lamp
18 10 ABS Pump Motor Relay
19 10 Air Conditioner Compressor Clutch Relay
20 20 Horn Relay
21 20 Ignition Coil, Fuel Injector, Oxygen Sensor
Relay
R1 Fuel Pump
R2 Not Used
R3 Automatic Shut Down
R4 Air Conditioner Compressor Clutch
R5 Horn
R6 ABS
R7 Not Used
R8 ABS Pump Motor
R9 Engine Starter Motor
R10 Rear Window Defogger
1999

Fuses and relays Jeep Wrangler (TJ 1997-2006)

Assignment of the fuses in the engine compartment (1999)

Amp Rating Description
2 40 Ignition Switch (Fuse (Passenger Compartment): “5”, “6”, “7”, “8”), Engine Starter Motor Relay
3 30 Ignition Switch (Cigar Lighter/Accessory Relay, Fuse (Passenger Compartment): “9”, “10”, “11”, “12”, “13”, “14”, “15”, “20”)
4 40 Fuse (Passenger Compartment): “1”, “2”
5 40 Cigar Lighter/Accessory Relay (Fuse (Passenger Compartment): “19”, “18”)
6 30 Automatic Shut Down Relay, Powertrain Control Module
7 Not Used
8 Not Used
9 20 Turn Signal/Hazard Switch
10 30 Headlamp Switch
11 40 HVAC Unit
12 Not Used
13 30 ABS Relay
14 40 ABS Pump Motor Relay
15 40 Rear Window Defogger Relay
16 10 Air Conditioner Compressor Clutch Relay
17 20 Horn Relay
18 20 Fuel Injector, Ignition Coi (2.5 L)
19 20 Fuel Pump Relay
20 10 Underhood Lamp, Left Courtesy Lamp, Right Courtesy Lamp, Radio, Data Link Connector, Dome Lamp (Hard Top), Sound Bar Dome Lamp (4 Speaker System),
21 10 ABS Pump Motor Relay
22 Not Used
23 Not Used
24 Not Used
25 20 Fog Lamp Relay No.1
26 Not Used
27 10 Leak Detection Pump, Oxygen Sensor
Relay
R1 Automatic Shut Down
R2 Air Conditioner Compressor Clutch
R3 Horn
R4 Fuel Pump
R5 ABS
R6 ABS Pump Motor
R7 Engine Starter Motor
R8 Rear Window Defogger
2000-2006

Fuses and relays Jeep Wrangler (TJ 1997-2006)

Assignment of the fuses in the engine compartment (2000-2006)

Amp Rating Description
1 40 Blower Motor Relay (HEVAC)
2 40 Rear Window Defogger Relay
3 40 Fuse (Passenger Compartment): “1”, “2”, “3” / Exterior Lighting
4 40 High Speed Radiator Fan, Low Speed Radiator Fan
5 20 2000-2002: Not Used;
2003-2006: Transmission Control Relay
6 30 / 40 2000-2001: ABS Pump Motor Relay (40A);

2002: Engine Starter Motor Relay, Ignition Switch (Fuse (Passenger Compartment): “5”, “6”, “7”, “8”) (40A);

2003-2006: Engine Starter Motor Relay, Ignition Switch (Fuse (Passenger Compartment): “5”, “6”, “7”, “8”) (30A)

7 20 / 30 2000-2001: ABS Relay (30A);

2002: Multi-Function Switch (20A);

2003-2006: Not Used

8 40 2000-2001: Engine Starter Motor Relay, Ignition Switch (Fuse (Passenger Compartment): “5”, “6”, “7”, “8”);

2002-2006: ABS Motor

9 20 / 30 2000-2004: Automatic Shut Down Relay, Powertrain Control Module (30A);

2005-2006: Automatic Shut Down (ASD) Relay, Powertrain Control Module (20A)

10 30 / 40 2000-2001: Headlamp Switch (30A);

2002-2006: HD/LP (40A)

11 20 Turn Signal/Hazard Switch / IOD Storage
12 30 ABS Valve
13 40 Ignition Switch (Fuse (Passenger Compartment): “17”, “18”, “19”)
14 30 2000-2001: Ignition Switch (Cigar Lighter/Accessory Relay, Fuse (Passenger Compartment): “9”, “10”, “11”, “12”, “13”, “14”, “15”, “22”), Clutch Pedal Position Switch (Manual Transmission);

2002: Ignition Switch (Fuse (Passenger Compartment): “9”, “10”, “11”, “12”, “13”, “14”, “15”, “20”), Clutch Pedal Position Switch (Manual Transmission);

2003-2006: Not Used

15 40 / 50 2000-2001: Cigar Lighter/Accessory Relay (Fuse (Passenger Compartment): “19”), Fuse (Passenger Compartment): “18” (40A);

2002: Fuse: “24” (50A);

2003-2006: Fuse: “26” / IOD (50A)

16 10 / 15 2000-2001: Oxygen Sensor (10A);

2002-2004: Oxygen Sensor Downstream Heater Relay (15A);

2005-2006: Not Used

17 20 2000-2001: Oxygen Sensor Downstream Heater Relay, Oxygen Sensor Upstream Heater Relay;

2003-2006: Power Outlet

18 20 Horn Relay
19 20 Multi-Function Switch (Front Fog Lamps)
20 15 2000-2002: Not Used;

2003-2006: Radio

21 10 Air Conditioner Compressor Clutch Relay
22 20 2000-2002: Not Used;

2003-2006: Ignition Switch (Fuse (Passenger Compartment): “9”, “10”, “11”, “12”, “13”, “14”, “22”), Clutch Pedal Position Switch (Manual Transmission)

23 20 Fuel Pump Relay
24 10 / 20 2000-2001: Not Used;

2002: Dome Lamp, Instrument Cluster, Data Link Connector, Radio, Courtesy Lamp, Underhood Lamp, Sound Bar Dome Lamp (10A)

2003-2006: Rear Locker Relay (Off-road Package), Front Locker (Off-road Package) (20A)

25 10 2000-2001: Dome Lamp, Instrument Cluster, Data Link Connector, Radio, Courtesy Lamp, Underhood Lamp, Sound Bar Dome Lamp;

2002-2006: Not Used

26 10 / 20 2000-2002: Ignition Coil, Fuel Injector (20A);

2003-2006: Dome Lamp, Instrument Cluster, Data Link Connector, Axle Lock Switch (Off-road Package), Courtesy Lamp, Compass/Temperature Mirror, Underhood Lamp (10A)

27 20 2000-2002: Not Used;

2003-2006: Multi-Function Switch

28 10 / 20 2000-2001: ABS (10A);

Clutch Override

2003-2006: Automatic Shut Down Relay, Ignition Coil, Fuel Injector, Coil Capacitor (20A)

Relay
R1 Automatic Shut Down
R2 Air Conditioner Compressor Clutch
R3 2000-2002: Not Used;

2003-2006: Transmission Control

R4 Engine Starter Motor
R5 ABS
R6 2000-2004: Oxygen Sensor Downstream Heater;

2005-2006: Not Used

R7 2000-2001: Oxygen Sensor Upstream Heater;

2002-2006: Fog Lamp

R8 Horn
R9 Fuel Pump
R10 Rear Window Defogger
R11 2003-2006: Front Locker (Off-road Package);

2005-2006: High Speed Radiator Fan (2.4 L PowerTech)

R12 2000-2001: ABS;

2003-2006: Rear Locker (Off-road Package);

2005-2006: Low Speed Radiator Fan (2.4 L PowerTech)

Video to the article

Fuse box location and diagrams: Jeep Wrangler (TJ; 1997-2006)
Jeep Wrangler TJ (1997-2006) Fuse Box Diagrams
Wiring DRL Halos in different way on Jeep TJ 1997-2006
Jeep TJ Won’t start Part 1
Jeep TJ blower fan issues? Here’s how to fix it!
How to replace your JEEP TJ blinker flasher relay

Leave a Reply

Your email address will not be published. Required fields are marked *