Fuses and relays Ford Expedition (UN93 1997-2002)

Fuse Layout Ford Expedition 1997-2002

Fuses and relays Ford Expedition (UN93 1997-2002)

Fuse box location

Passenger compartment

The fuse panel is located below and to the left of the steering wheel by the brake pedal.Fuses and relays Ford Expedition (UN93 1997-2002)

Fuses and relays Ford Expedition (UN93 1997-2002)

Engine compartment fuse boxes

The power distribution box is located in the engine compartment.

1997-1998Fuses and relays Ford Expedition (UN93 1997-2002)

1999-2002Fuses and relays Ford Expedition (UN93 1997-2002)

Fuses and relays Ford Expedition (UN93 1997-2002)

The primary battery fuses (megafuses) are located in the engine compartment near the battery.
Fuses and relays Ford Expedition (UN93 1997-2002)

The engine mini fuses are located on the drivers side of the engine compartment.
Fuses and relays Ford Expedition (UN93 1997-2002)

Fuse box diagrams

1997

Passenger compartment

Fuses and relays Ford Expedition (UN93 1997-2002)

Assignment of the fuses in the Passenger compartment (1997)

Slot number Amperage Description
1 15 amp Stop/turn lamps
2 5 amp Instrument cluster, trip computer
3 25 amp Cigar lighter
4 5 amp Autolamp module, head lamp relay, remote entry anti-theft with personality module (RAP), power mirrors
5 15 amp Air condition (A/C) clutch, hybrid fan relay, backup lamps, speed control, DRL, instrument panel blend door actuator, electronic variable orifice (EVO) steering module
6 5 amp Generic electronic module (GEM), shift interlock, air suspension module, heated backlite (HBL) relay, steering sensor, trip computer, compass
7 5 amp Console blower, auxiliary blower relay coil
8 5 amp GEM, radio, RAP module
9 Not used
10 Not used
11 30 amp Front wiper motor, washer motor
12 5 amp OBDII scan tool connector
13 15 amp Brake on/off switch, brake pressure switch
14 15 amp Interior lamps, delayed accessory relay, rear wiper relays
15 5 amp GEM, passive anti-theft system (PATS) module
16 20 amp High beam headlamps, high beam indicator
17 10 amp Heated mirrors, heated mirror switch
18 5 amp Instrument and switch illumination
19 10 amp Airbag diagnostic monitor, instrument cluster
20 5 amp GEM, air suspension module
21 15 amp Starter relay, junction box fuse #20
22 10 amp Airbag diagnostic monitor
23 10 amp Electronic flasher, 4WD vacuum solenoids, trailer tow battery charge relay, console climate door actuator, auxiliary blend and mode door actuators, auxiliary pot switching module
24 10 amp I/P blower relay, junction fuse box #7
25 5 amp 4WABS module, 4WABS red lamps relay
26 10 amp Right low beam head lamp, DRL module
27 5 amp Foglamp relay, main lamp switch
28 10 amp Left low beam headlamp
29 5 amp Auto lamp module, instrument cluster, transmission control indicator light and switch
30 30 amp Ignition coils, PCM relay, PATS module, radio capacitors
31 Not used
Slot number Amperage Description
1 Interior lamp relay
2 Battery saver relay
3 HBL relay
4 One touch down relay
5 Accessory delay relay
Engine compartment

Fuses and relays Ford Expedition (UN93 1997-2002)

Assignment of the fuses in the Power distribution box (1997)

Slot number Amp Rating Circuits protected
1 20 amp Trailer tow backup & tail lamps
2 10 amp Airbag diagnostic monitor
3 30 amp Power locks
4 15 amp Air suspension
5 20 amp Horn
6 30 amp Engine minifuse box fuses #3 and #5
7 15 amp Park and tail lamps
8 30 amp Headlamps
9 15 amp Fog lamps and DRL
10 25 amp Auxiliary instrument panel (I/P) power point
11 25 amp Auxiliary console power point
12 10 amp Rear wiper
13 30 amp Auxiliary blower
14 60 amp Four wheel anti-lock brake system (4WABS)
15 50 amp Air suspension compressor
16 40 amp Trailer tow battery charge, engine minifuse box fuse #2, engine minifuse box fuse #4
17 30 amp Four-wheel drive (4WD) transfer case motor and clutch
18 30 amp Driver power seat
19 20 amp Fuel pump
20 50 amp Junction box ignition switched feed
21 50 amp Junction box ignition switched feed
22 50 amp Junction box battery feed
23 40 amp Front blower
24 30 amp Powertrain control module power
25 30 C.B. Windows
26 not used
27 40 amp Heated backlite and mirrors
28 30 amp Trailer tow electric brake
29 30 amp Hybrid fan, moon roof, flip windows
Slot number Description
1 not used
2 PCM diode
Slot number Description
1 Windshield wipers high/low speed
2 Windshield wipers run/park
3 Front washer pump relay
4 Fuel pump relay
5 Horn relay
6 PCM power relay
Primary battery fuses (megafuses) (1997)

Fuses and relays Ford Expedition (UN93 1997-2002)

Location Amperage Description
1 175 Power Network Box Megafuse
2 175 Alternator Megafuse
3 20 Alternator Field Minifuse
Engine mini fuse box (1997)

Fuses and relays Ford Expedition (UN93 1997-2002)

Slot Number Amp Rating Circuits Protected
1 5 amp Powertrain Control Module (PCM)
2 20 amp Trailer Tow Stop/Turn Lamps
3 10 amp Audio Rear Integrated Control Panel (RICP), Compact Disc Changer, Radio
4 10 amp Running Board Lamps
5 20 amp Amplifier, Subwoofer Amplifier
6 Not Used

1998

Passenger compartment

Fuses and relays Ford Expedition (UN93 1997-2002)

Assignment of the fuses in the Passenger compartment (1998)

Amp Rating Description
1 15A Flasher Relay
2 5A Instrument Cluster, Overhead Trip Computer (OTC) Module
3 25A Cigar Lighter
4 5A Park Lamp Relay, Headlamp Relay, Autolamp Module, Remote Anti-Theft Personality (RAP) Module, Power Mirror Switch
5 15A Digital Transmission Range (DTR) Sensor, Daytime Running Lamps (DRL) Module, Speed Control Servo/Amplifier Assembly, Heater-A/C Control Assembly, Blend Door Actuator, Electronic Variable Orifice (EVO) Module
6 5A Shift Lock Actuator, Generic Electronic Module (GEM), 4 Wheel Air Suspension (4WAS) Module, Compass Sensor, Steering Wheel Rotation Sensor, Heated Grid Relay, Overhead Trip Computer (OTC) Module
7 5A Auxiliary A/C Relay, Console Blower Motor
8 5A Radio, Main Light Switch, Remote Anti-Theft Personality (RAP) Module
9 Not Used
10 Not Used
11 30A Washer Pump Relay, Wiper Run/Park Relay, Wiper Hi/Lo Relay, Windshield Wiper Motor, Rear Wiper Pump Relay
12 5A Data Link Connector (DLC)
13 15A Brake On/Off (BOO) Switch, Brake Pressure Switch
14 15A Battery Saver Relay, Interior Lamp Relay
15 5A Generic Electronic Module (GEM), Passive Anti-Theft System (PATS) Module
16 20A Instrument Cluster (W/O DRL), Daytime Running Lamps (DRL) Module, Hi-Beam Headlamps (Power supplied through Multi-Function Switch)
17 10A Heated Backlight Switch, Left Power/Heated Signal Mirror, Right Power/Heated Signal Mirror
18 5A Main Light Switch, Generic Electronic Module (GEM), Instrument Illumination (Power supplied through Main Light Switch)
19 10A Instrument Cluster, Air Bag Diagnostic Monitor
20 5A 4 Wheel Air Suspension (4WAS), Generic Electronic Module (GEM)
21 15A Digital Transmission Range (DTR) Sensor, Junction Box Fuse/Relay Panel (Fuse 20)
22 10A Air Bag Diagnostic Monitor
23 10A Trailer Tow Battery Charge Relay, 4X4 Center Axle Disconnect solenoid, 4X2 Center Axle Disconnect Solenoid, Function Selector Switch, Rear Integrated Control Panel, Recirculation Vacuum Solenoid, Auxiliary A/C Mode Acturator, Auxiliary A/C Control Module
24 10A Function Selector Swatch
25 5A 4 Wheel Anti-Lock Brake System (4WABS) Module, 4WABS Relay
26 10A Daytime Running Lamps (DRL) Module, Right Headlamp (Power supplied through Multi-Function Switch)
27 5A Main Light Switch, Fog Lamp Relay
28 10A Left Headlamp
29 5A Autolamp Module, Instrument Cluster, Transmission Control Switch (TCS)
30 30A Radio Noise Capacitor, Ignition Coil, PCM Power Diode, Coil On Plugs
31 Not Used
Engine compartment

Fuses and relays Ford Expedition (UN93 1997-2002)

Assignment of the fuses in the Power distribution box (1998)

Amp Rating Description
1 20 A* Trailer Tow Running Lamp Relay, Trailer Tow Backup Lamp Relay
2 10A* Air Bag Diagnostic Monitor
3 30 A* All Unlock Relay, All Lock Relay, Driver’s Unlock Relay
4 15A* Air Suspension Sendee Switch
5 20 A* Horn Relay
6 30 A* Radio, Premium Sound Amplifier, CD Changer, Rear Integrated Control Panel, Sub-Woofer Power (Fuse 3 & Fuse 5)
7 15A* Main Light Switch, Park Lamp Relay
8 30 A* Main Light Switch, Headlamp Relay, Multi-Function Switch
9 15A* Daytime Running Lamps (DRL) Module, Fog Lamp Relay
10 25 A* I/P Auxiliary Power Socket
11 25 A* Console Auxiliary Power Socket
12 10A* Rear Wiper Up Motor Relay, Rear Wiper Down Motor Relay
13 30A** Auxiliary A/C Relay
14 60A** 4 Wheel Anti-Lock Brake System (4WABS) Module
15 50A** Air Suspension Solid State Compressor Relay
16 40A** Trailer Tow Battery Charge Relay, Engine Fuse Module (Fuse 2)
17 30A** Shift on the Fly Relay, Transfer Case Shift relay
18 30A** Power Seat Control Swatch
19 20A** Fuel Pump Relay
20 50A** Ignition Switch (B4 & B5)
21 50A** Ignition Switch (B1 & B3)
22 50A** Junction Box Fuse/Relay Panel Battery Feed
23 40A** I/P Blower Relay
24 30A** PCM Power Relay, Engine Fuse Module (Fuse 1)
25 30A CB Junction Box Fuse/Relay Panel, ACC Delay Relay
26 Not Used
27 40A** Junction Box Fuse/Relay Panel, Heated Grid Relay
28 30A** Trailer Electronic Brake Controller
29 30A** Flip Window Relay, Hybrid Cooling Fan Relay
* Mini Fuses
** Maxi Fuses
Primary battery fuses (megafuses) (1998)

Fuses and relays Ford Expedition (UN93 1997-2002)

Location Amperage Description
1 175 Power Network Box Megafuse
2 175 Alternator Megafuse
3 20 Alternator Field Minifuse
Engine mini fuse box (1998)

Fuses and relays Ford Expedition (UN93 1997-2002)

Slot Number Amp Rating Circuits Protected
1 5 amp Powertrain Control Module (PCM)
2 20 amp Trailer Tow Stop/Turn Lamps
3 10 amp Audio Rear Integrated Control Panel (RICP), Compact Disc Changer, Radio
4 10 amp Running Board Lamps
5 20 amp Amplifier, Subwoofer Amplifier
6 Not Used

1999

Passenger compartment

Fuses and relays Ford Expedition (UN93 1997-2002)

Assignment of the fuses in the Passenger compartment (1999)

Amp Rating Description
1 25A Audio
2 5A Overhead Trip Computer, Electronic Automatic Temperature Control (EATC), Powertrain Control Module (PCM), Cluster
3 20A Cigar Lighter, OBD-II Scan Tool Connector
4 15A Autolamp Module, Remote Entry Module, Mirrors, Air Suspension Switch
5 15A AC Clutch Relay, Speed Control Module, Reverse Lamp, EVO Module, Climate Mode Switch (Front Blower Relay), Daytime Running Lamp Relay
6 5A Cluster, Overhead Trip Computer, Compass, Brake Shift Interlock Solenoid, Air Suspension Module, GEM Module, EVO Steering Sensor
7 5A Aux A/C Blower Relay, Console Blower
8 5A Radio, Remote Entry Module, GEM Module
9 Not Used
10 Not Used
11 30A Front Washer Pump Relay, Wiper Run/Park Relay, Wiper Hi/LO Relay, Windshield Wiper Motor, Rear Washer Pump Relay
12 Not Used
13 20A Stop Lamp Switch (Lamps), Turn/Hazard Flasher, Speed Control Module
14 15A Rear Wipers, Running Board Lamps, Battery Saver Relay, Interior Lamp Relay, Accessoiy Delay Relay (Power Windows)
15 5A Stop Lamp Switch, (Speed Control, Brake Shift Interlock, ABS, PCM Module Inputs), GEM Module
16 20A Headlamps (Hi Beams), Cluster (Hi Beam Indicator)
17 10A Heated Mirrors, Heated Grid Switch Indicator
18 5A Instrument Illumination (Dimmer Switch Power)
19 Not Used
20 5A Audio, Four Wheel Air Suspension (4WAS) Module, GEM Module
21 15A Starter Relay, Fuse 20
22 10A Air Bag Module
23 10A Aux A/C, Heated Seats, Trailer Tow” Battery Charge, Turn/Hazard Flasher, Console Blower Door Actuator
24 10A Climate Mode Switch (Blower Relay), EATC (via fuse 7), EATC Blower Relay
25 5A 4 Wheel Anti-Lock Brake System (4WABS) Module
26 10A Right Side Low Beam Headlamp
27 5A Foglamp Relay and Foglamp Indicator
28 10A Left Side Low Beam Headlamp
29 5A Autolamp Module, Transmission Overdrive Control Switch
30 30A Passive Anti Theft Transceiver, Cluster, Ignition Coils, Powertrain Control Module Relay
31 10A Rear Integrated Control Panel (Audio), CD Player
Relay 1 Interior Lamp Relay
Relay 2 Battery Saver Relay
Relay 3 Rear Window Defroster Relay
Relay 4 One Touch Down Window Relay
Relay 5 ACC Delay Relay
Engine compartment

Fuses and relays Ford Expedition (UN93 1997-2002)

Assignment of the fuses in the Power distribution box (1999)

Amp Rating Description
1 25A * Power Point
2 30 A* Powertrain Control Module
3 30 A* Headlamps/Autolamps
4 2 5 A* Console PowerPoint
5 20 A* Trailer Tow Backup/Park Lamps
6 15A* Parklamps/Autolamps
7 20 A* Horn
8 30 A* Power Door Locks
9 15A* Daytime Running Lamps (DRL), Fog Lamps
10 20 A* Fuel Pump
11 20 A* Alternator Field
12 10 A* Rear Wipers
13 Not Used
14 Not Used
15 10 A* Running Board Lamps
16 Not Used
17 Not Used
18 15 A* Powertrain Control Module, Fuel Injectors, Fuel Pump, Mass Air Flow Sensor
19 10 A* Trailer Tow Stop and Right Turn Lamp
20 10 A* Trailer Tow Stop and Left Turn Lamp
21 Not Used
22 Not Used
23 15 A* Powertrain Control Module, HEGO Sensors, Canister Vent
24 15 A* Powertrain C ontrol Module, Automatic Transmission, CMS Sensor
101 30A** Trailer Tow Battery Charge
102 50A** Four Wheel Antilock Brake Module
103 50A** Junction Block Battery Feed
104 30A** 4×4 Shift Motor & Clutch
105 40A** Climate Control Front Blower
106 Not Used
107 Not Used
108 30A** Trailer Tow Electric Brake
109 50A** Air Suspension Compressor
110 30A** Moonroof, Flip Windows and Heated Seats
111 50A** Ignition Switch Battery Feed (Start Circuit)
112 30A** Drivers Power Seat, Adjustable Pedals
113 50A** Ignition Switch Battery Feed (Run and Accessoiy Circuits)
114 30A** Climate Control Auxiliary Blower
115 Not Used
116 40A** Rear Window Defroster, Heated Mirrors
117 Not Used
118 Not Used
201 Trailer Tow Park Lamp Relay
202 Front Wiper Run/Park Relay
203 Trailer Tow Backup Lamp Relay
204 A/C Clutch Relay
205 Horn Relay
206 Foglamp Relay
207 Front Washer Pump Relay
208 Rear Washer Pump Relay
209 Front Wiper Hi/Lo Relay
210 Not Used
211 Not Used
212 Rear Wiper Up Relay
213 Rear Wiper Down Relay
301 Fuel Pump Relay
302 Trailer Tow Battery Charge Relay
303 Not Used
304 Powertrain Control Module Relay
401 Not Used
501 Powertrain Control Module Diode
502 A/C Clutch Diode
503 Not Used
601 30A Delayed Accessory (Power Windows, Flip Windows, Moonroof)
602 Not Used
* Mini fuses
** Maxi fuses

2000

Passenger compartment

Fuses and relays Ford Expedition (UN93 1997-2002)

Assignment of the fuses in the Passenger compartment (2000)

Amp Rating Passenger Compartment Fuse Panel Description
1 25A Audio
2 5A Overhead Trip Computer, Electronic Automatic Temperature Control (EATC), Powertrain Control Module (PCM), Cluster
3 20 A Cigar Lighter, OBD-II Scan Tool Connector
4 7.5A Remote Entry Module, Mirrors, Memory Functions (Seats and Pedals)
5 15A Speed Control Module, Reverse Lamp, EVO Module, Climate Mode Switch (Front Blower Relay), Daytime Running Lamp Relay, Reverse Sensing System, Autolock, E/C Mirror
6 5A Cluster, Overhead Trip Computer, Compass, Brake Shift Interlock Solenoid, Air Suspension Module, GEM Module, EVO Steering Sensor, Heated Mirror, Rear Defroster, Reverse Sensing System
7 5A Aux A/C Blower Relay (via fuse 22)
8 5A Radio, Remote Entry Module, GEM Module
9 Not Used
10 Not Used
11 30A Front Washer Pump Relay, Wiper Run/Park Relay, Wiper Hi/LO Relay, Windshield Wiper Motor, Rear Washer Pump Relay
12 15A Air Suspension Switch
13 20 A Stop Lamp Switch (Lamps), Turn/Hazard Flasher, Speed Control Module
14 15A Rear Wipers, Running Board Lamps, Battery Saver Relay, Interior Lamp Relay, Accessory Delay Relay (Power Windows, Moonroof, Flip Windows)
15 5A Stop Lamp Switch, (Speed Control, Brake Shift Interlock, ABS, PCM Module Inputs, Air Suspension Module, Autolock), GEM Module
16 20 A Headlamps (Hi Beams), Cluster (Hi Beam Indicator)
17 10A Heated Mirrors, Heated Grid Switch Indicator
18 5A Instrument Illumination (Dimmer Switch Power)
19 Not Used
20 5A Audio, Air Suspension Module, GEM Module, Memory Module
21 15A Starter Relay, Fuse 20, Transmission Range Switch
22 10A Air Bag Module, Climate Mode Switch (Blower Relay), EATC, EATC Blower Relay, Feeds Fuse 7
23 10A Aux A/C, Heated Seats, Trailer Tow Battery Charge, Turn/Hazard Flasher, 4×4 Clutch Relay, Overhead Console, E/C Mirror, 4 Wheel Anti-Lock Brake System (4WABS) Module
24 Not Used
25 Not Used
26 10A Right Side Low Beam Headlamp
27 5A Foglamp Relay and Foglamp Indicator
28 10A Left Side Low Beam Headlamp
29 5A Autolamp Module, Transmission Overdrive Control Swatch
30 30A Passive Anti Theft Transceiver, Cluster, Ignition Coils, Powertrain Control Module Relay
31 10A Rear Integrated Control Panel (Audio), CD Player
Relay 1 Interior Lamp Relay
Relay 2 Battery Saver Relay
Relay 3 Rear Window Defroster Relay
Relay 4 One Touch Down Window Relay
Relay 5 ACC Delay Relay
Engine compartment

Fuses and relays Ford Expedition (UN93 1997-2002)

Assignment of the fuses in the Power distribution box (2000)

Amp Rating Power Distribution Box Description
1 20A * Power Point
2 30A* Powertrain Control Module
3 30A* Headlamps/Autolamps
4 20A* Console Powerpoint
5 20A* Trailer Tow Backup/Park Lamps
6 15 A* Parklamps/Autolamps, Feeds Passenger Compartment Fuse 18
7 20A* Horn
8 30A* Power Door Locks
9 15 A* Daytime Running Lamps (DRL), Fog Lamps
10 20A* Fuel Pump
11 20A* Alternator Field
12 10 A* Rear Wipers
13 15 A* A/C Clutch
14 Not Used
15 10 A* Running Board Lamps
16 Not Used
17 10 A* Flip Windows
18 15 A* Powertrain Control Module, Fuel Injectors, Fuel Pump, Mass Air Flow Sensor
19 10 A* Trailer Tow Stop and Right Turn Lamp
20 10 A* Trailer Tow Stop and Left Turn Lamp
21 Not Used
22 Not Used
23 15 A* HEGO Sensors, Canister Vent, Automatic Transmission, CMS Sensor
24 Not Used
101 30A** Trailer Tow Battery Charge
102 50A** Four Wheel Antilock Brake Module
103 50A** Junction Block Battery Feed
104 30A** 4×4 Shift Motor & Clutch
105 40A** Climate Control Front Blower
106 Not Used
107 Not Used
108 30A** Trailer Tow Electric Brake
109 50A** Air Suspension Compressor
110 30A** Heated Seats
111 40A** Ignition Switch Battery Feed (Run/Start Circuit)
112 30A** Drivers Power Seat, Adjustable Pedals, Memory Module
113 40A** Ignition Switch Battery Feed (Run and Accessory Circuits)
114 30A** Climate Control Auxiliary Blower
115 Not Used
116 40A** Rear Window Defroster, Heated Mirrors
117 Not Used
118 Not Used
201 Trailer Tow Park Lamp Relay
202 Front Wiper Run/Park Relay
203 Trailer Tow Backup Lamp Relay
204 A/C Clutch Relay
205 Rear Wiper Down
206 Foglamp Relay
207 Front Washer Pump Relay
208 Rear Washer Pump Relay
209 Rear Wiper Up
301 Fuel Pump Relay
302 Trailer Tow Battery Charge Relay
303 Wiper Hi/Lo Relay
304 Powertrain Control Module Relay
401 Not Used
501 Powertrain Control Module Diode
502 A/C Clutch Diode
503 Not Used
601 30A Delayed Accessory (Power Windows, Flip Windows, Moonroof)
602 Not Used
* Mini fuses
** Maxi fuses

2001, 2002

Passenger compartment

Fuses and relays Ford Expedition (UN93 1997-2002)

Assignment of the fuses in the Passenger compartment (2001, 2002)

Amp Rating Passenger Compartment Fuse Panel Description
1 25A Audio
2 5A Overhead Trip Computer, Electronic Automatic Temperature Control (EATC), Powertrain Control Module (PCM), Cluster
3 20A Cigar Lighter, OBD-II Scan Tool Connector
4 7.5A Remote Entry Module, Mirrors, Memory Functions (Seats and Pedals)
5 15A Speed Control Module, Reverse Lamp, EVO Module, Climate Mode Switch (Front Blower Relay), Daytime Running Lamp Relay, Reverse Sensing System, Autolock, E/C Mirror
6 5A Cluster, Overhead Trip Computer, Compass, Brake Shift Interlock Solenoid, Air Suspension Module, GEM Module, EVO Steering Sensor, Heated Mirror, Rear Defroster, Reverse Sensing System
7 5A Aux A/C Blower Relay (via fuse 22)
8 5A Radio, Remote Entry Module, GEM Module
9 Not Used
10 Not Used
11 30A Front Washer Pump Relay, Wiper Run/Park Relay, Wiper Hi/LO Relay, Windshield Wiper Motor, Rear Washer Pump Relay
12 15A Air Suspension Switch
13 20A Stop Lamp Switch (Lamps), Turn/Hazard Flasher, Speed Control Module
14 15A Rear Wipers, Running Board Lamps, Battery Saver Relay, Interior Lamp Relay, Accessory Delay Relay (Power Windows, Moonroof, Flip Windows)
15 5A Stop Lamp Switch, (Speed Control, Brake Shift Interlock, ABS, PCM Module Inputs, Air Suspension Module, Autolock), GEM Module
16 20A Headlamps (Hi Beams), Cluster (Hi Beam Indicator)
17 10A Heated Mirrors, Heated Grid Switch Indicator
18 5A Instrument Illumination (Dimmer Switch Power)
19 Not Used
20 5A Audio, Air Suspension Module, GEM Module, Memory Module
21 15A Starter Relay, Fuse 20, Transmission Range Switch
22 10A Air Bag Module, Intelligent Passenger Airbag Deactivation Module
23 10A Aux A/C, Heated Seats, Trailer Tow Battery Charge, Turn/Hazard Flasher, 4×4 Clutch Relay, Overhead Console, E/C Mirror, 4 Wheel Anti-Lock Brake System (4WABS) Module
24 10A EATC Module, EATC Blower Relay, Climate Control Switch Assembly, Feeds Fuse 7
25 Not Used
26 10A Right Side Low Beam Headlamp
27 5A Foglamp Relay and Foglamp Indicator
28 10A Left Side Low Beam Headlamp
29 5A Autolamp Module, Transmission Overdrive Control Switch
30 30A Passive Anti Theft Transceiver, Cluster, Ignition Coils, Powertrain Control Module Relay
31 10A Rear Integrated Control Panel (Audio), CD Player
Relay 1 Interior Lamp Relay
Relay 2 Battery Saver Relay
Relay 3 Rear Window Defroster Relay
Relay 4 One Touch Down Window Relay
Relay 5 ACC Delay Relay
Engine compartment

Fuses and relays Ford Expedition (UN93 1997-2002)

Assignment of the fuses in the Power distribution box (2001, 2002)

Amp Rating Power Distribution Box Description
1 20A * Power Point
2 30A* Powertrain Control Module
3 30A* Headlamps/Autolamps
4 20A* Console PowerPoint
5 20A* Trailer Tow Backup/Park Lamps
6 15 A* Parklamps/Autolamps, Feeds Passenger Compartment Fuse 18
7 20A* Horn
8 30A* Power Door Locks
9 15 A* Daytime Running Lamps (DRL), Fog Lamps
10 20A* Fuel Pump
11 20A* Alternator Field
12 10 A* Rear Wipers
13 15 A* A/C Clutch
14 Not Used
15 10 A* Running Board Lamps
16 Not Used
17 10 A* Flip Windows
18 15 A* Powertrain Control Module, Fuel Injectors, Fuel Pump, Mass Air Flow Sensor
19 10 A* Trailer Tow Stop and Right Turn Lamp
20 10 A* Trailer Tow Stop and Left Turn Lamp
21 Not Used
22 Not Used
23 15 A* HEGO Sensors, Canister Vent, Automatic Transmission, CMS Sensor
24 Not Used
101 30A** Trailer Tow Battery Charge
102 50A** Four Wheel Antilock Brake Module
103 50A** Junction Block Battery Feed
104 30A** 4×4 Shift Motor & Clutch
105 40A** Climate Control Front Blower
106 Not Used
107 Not Used
108 30A** Trailer Tow Electric Brake
109 50A** Air Suspension Compressor
110 30A** Heated Seats
111 40A** Ignition Switch Battery Feed (Run/Start Circuit)
112 30A** Drivers Power Seat, Adjustable Pedals, Memory Module
113 40A** Ignition Switch Battery Feed (Run and Accessory Circuits)
114 30A** Climate Control Auxiliary Blower
115 Not Used
116 40A** Rear Window Defroster, Heated Mirrors
117 Not Used
118 Not Used
201 Trailer Tow Park Lamp Relay
202 Front Wiper Run/Park Relay
203 Trailer Tow Backup Lamp Relay
204 A/C Clutch Relay
205 Rear Wiper Down
206 Foglamp Relay
207 Front Washer Pump Relay
208 Rear Washer Pump Relay
209 Rear Wiper Up
301 Fuel Pump Relay
302 Trailer Tow Battery Charge Relay
303 Wiper Hi/Lo Relay
304 Powertrain Control Module Relay
401 Not Used
501 Powertrain Control Module Diode
502 A/C Clutch Diode
503 Not Used
601 30A Delayed Accessory (Power Windows, Flip Windows, Moonroof)
602 Not Used
* Mini fuses
** Maxi fuses

Video to the article

Ford Expedition (1997-2002) Fuse Box Diagrams
Fuse box location and diagrams: Ford Expedition (1997-1998)
Fuse box location and diagrams: Ford Expedition (1999-2002)
2001 Expedition Fuel Pump Relay \u0026 Fuse, Starter Fuse \u0026 Relay
Fuse box location and diagrams: Ford Expedition (2003-2006)
1999 Ford Expedition Starter Fuses, Circuit Explained

Leave a Reply

Your email address will not be published. Required fields are marked *